Fabrication and Performance Evaluation of Poly(sulfonate(amide) ester)-based Ultrafiltration Membranes

GONG En-hui

doi:10.14028/j.cnki.1003-3726.2025.25.159

您当前的位置：

首页 >

文章列表页 >

Fabrication and Performance Evaluation of Poly(sulfonate(amide) ester)-based Ultrafiltration Membranes

更新时间：2025-10-30

- Fabrication and Performance Evaluation of Poly(sulfonate(amide) ester)-based Ultrafiltration Membranes
- Polymer Bulletin Vol. 38, Issue 11, Pages: 1685-1692(2025)
- 作者机构：
  
  山东工业职业学院冶金与汽车工程学院，淄博 256414
- 作者简介：
- 基金信息：
- DOI：10.14028/j.cnki.1003-3726.2025.25.159
  CLC：
- Received：01 July 2025，
  
  Accepted：24 July 2025，
  
  Published Online：19 September 2025，
  
  Published：20 November 2025
- 稿件说明：
移动端阅览
巩恩辉. 聚硫酸(酰胺)酯超滤膜制备及性能研究. 高分子通报, 2025, 38(11), 1685-1692.

Gong, E. H. Fabrication and performance evaluation of poly(sulfonate(amide) ester)-based ultrafiltration membranes. Polym. Bull. (in Chinese), 2025, 38(11), 1685-1692.
巩恩辉. 聚硫酸(酰胺)酯超滤膜制备及性能研究. 高分子通报, 2025, 38(11), 1685-1692. DOI： 10.14028/j.cnki.1003-3726.2025.25.159.

Gong, E. H. Fabrication and performance evaluation of poly(sulfonate(amide) ester)-based ultrafiltration membranes. Polym. Bull. (in Chinese), 2025, 38(11), 1685-1692. DOI： 10.14028/j.cnki.1003-3726.2025.25.159.

摘要

以聚硫酸(酰胺)酯为原料、

-二甲基甲酰胺(DMF)为溶剂，聚乙烯吡咯烷酮(PVP)为添加剂，通过相转化法制备了具有高水渗透性和优异抗污染性能的新型聚硫酸(酰胺)酯超滤膜。实验结果表明，随着聚硫酸(酰胺)酯含量的增加，超滤膜的亲水性和抗污染性能显著提高。当聚硫酸(酰胺)酯质量分数为18 wt%时，所制备的超滤膜对腐植酸溶液的截留率达到88.65%，同时保持85.25%的通量恢复率，这为高性能超滤膜的制备提供了重要参考。

Abstract

Novel poly(sulfonate(amide) ester) ultrafiltration membranes were prepared using polysulfonamide as the raw material

-dimethylformamide (DMF) as the solvent

and polyvinylpyrrolidone (PVP) as the additive

via

phase inversion. The results showed that with an increase in the Poly(sulfonate(amide) ester) content

the hydrophilicity and antifouling properties of the ultrafiltration membranes increased. When the poly(sulfonate(amide) ester) content was 18 wt%

the rejection rate of the prepared ultrafiltration membrane for humic acid solution was 88.65%

and it could maintain a flux recovery rate of 85.25%. This has profound significance for the preparation of high-performance ultrafiltration membranes.

关键词

Keywords

references

文欣 , 海玉琰 , 何灿 , 马瑞 , 熊日华 , 刘淑琴 . XDLVO理论分析矿井水中PES超滤膜的耦合污染 . 膜科学与技术 , 2024 , 44 ( 4 ), 147 – 156 .

蒋亚妮 , 赵自豪 , 苏茜薇 , 朱礼恒 , 田华 , 薛云云 , 杜斌 , 钱佳成 , 王建宇 , 凌君 , 朱宝库 . 丙烯酸酯类两亲性共聚物超滤膜的制备及性能 . 膜科学与技术 , 2024 , 44 ( 5 ), 32 – 39 .

刘春波 , 刘玮 , 徐瑞松 , 唐石云 , 赵蔚 , 朱志扬 , 何沛 , 由博妍 , 冯欣 , 张冉 , 侯蒙杰 , 李琳 , 王同华 . 高通量聚间苯二甲酰间苯二胺超滤膜的制备与性能研究 . 膜科学与技术 , 2024 , 44 ( 5 ), 100 – 107 .

王远远 , 王仪 , 黄思怡 , 蔡玮玮 . 高盐有机废水超滤处理的膜污染机制和分离效果研究 . 膜科学与技术 , 2024 , 44 ( 6 ), 26 – 36 .

杜致尧 , 厍景国 , 管旺旺 , 闫弘津 , 武春瑞 , 吕晓龙 . 基于交联分子改性的抗污染超滤膜研制 . 膜科学与技术 , 2024 , 44 ( 6 ), 18 – 25 .

丁莹 , 薛雅文 , 张尹佳 , 章雨菡 , 徐志超 . MMA-co-ILS对PVDF超滤膜的亲水性改性及其抗菌性研究 . 南京晓庄学院学报 , 2024 , 40 ( 6 ), 37 – 42 .

解静静 , 何经纬 , 李海霞 . PTFE改性膜的抗污染性能研究 . 环境保护与循环经济 , 2025 , 45 ( 1 ), 24 – 28 .

马凌飞 , 王薇 , 王佳琦 , 李玮阳 . 高性能FeCl 2 ·4H 2 O/聚硫酸酯(PSE)中空纤维共混超滤膜性能和结构的探究 . 天津化工 , 2024 , 38 ( 5 ), 38 – 42 .

孙凌昊 , 王佳琦 , 李佩佩 , 曾凡夫 , 许白羽 , 王薇 . 基于卤化锂改性的聚硫酸酯(PSE)超滤膜的制备及研究 . 山东化工 , 2024 , 53 ( 20 ), 13 – 17 .

Ma, Y. X. ; Zhao, K. ; Wang, D. D. ; Guo, J. F. ; Wei, X. ; Yang, W. J. ; Zhao, J. Q. ; Li, Z. Y . MnFe 2 O 4 composited polyvinylidene fluoride catalytic ultrafiltration membrane via peroxymonosulfate activation for humic acid treatment: Exploration of synergistic mechanisms . Sep. Purif. Technol. , 2024 , 332 , 125708 .

Abdolmaleki, H. R. ; Mousavi, S. A. ; Heydari, H . Novel positively charged PVDF/SPES membranes surface grafted by hyperbranched polyethyleneimine (HBPEI): Fabrication, characterization, antifouling properties, and performance on the removal of cationic E-coat paint . Polym. Test. , 2023 , 122 , 108020 .

Ji, Y. ; Yang, X. L. ; Ji, Z. ; Zhu, L. H. ; Ma, N. N. ; Chen, D. J. ; Jia, X. B. ; Tang, J. M. ; Cao, Y. L . DFT-calculated IR spectrum amide Ⅰ, Ⅱ, and Ⅲ band contributions of N -methylacetamide fine components . ACS Omega , 2020 , 5 ( 15 ), 8572 – 8578 .

Kallem, P. ; Ibrahim, Y. ; Hasan, S. W. ; Show, P. L. ; Banat, F . Fabrication of novel polyethersulfone (PES) hybrid ultrafiltration membranes with superior permeability and antifouling properties using environmentally friendly sulfonated functionalized polydopamine nanofillers . Sep. Purif. Technol. , 2021 , 261 , 118311 .

Zhao, C. S. ; Xue, J. M. ; Ran, F. ; Sun, S. D . Modification of polyethersulfone membranes—a review of methods . Prog. Mater. Sci. , 2013 , 58 ( 1 ), 76 – 150 .

Xu, Z. W. ; Wu, T. F. ; Shi, J. ; Teng, K. Y. ; Wang, W. ; Ma, M. J. ; Li, J. ; Qian, X. M. ; Li, C. Y. ; Fan, J. T . Photocatalytic antifouling PVDF ultrafiltration membranes based on synergy of graphene oxide and TiO 2 for water treatment . J. Membr. Sci. , 2016 , 520 , 281 – 293 .

Liu, F. ; Hashim, N. A. ; Liu, Y. T. ; Moghareh Abed, M. R. ; Li, K . Progress in the production and modification of PVDF membranes . J. Membr. Sci. , 2011 , 375 ( 1-2 ), 1 – 27 .

Zhou, Y. ; Xi, D. L . Porous PVDF/TPU blends asymmetric hollow fiber membranes prepared with the use of hydrophilic additive PVP (K30) . Desalination , 2008 , 223 ( 1-3 ), 438 – 447 .

Zhao, X. T. ; Zhang, R. N. ; Liu, Y. N. ; He, M. R. ; Su, Y. L. ; Gao, C. J. ; Jiang, Z. Y . Antifouling membrane surface construction: chemistry plays a critical role . J. Membr. Sci. , 2018 , 551 , 145 – 171 .

Rana, D. ; Matsuura, T . Surface modifications for antifouling membranes . Chem. Rev. , 2010 , 110 ( 4 ), 2448 – 2471 .

Li, P. J. ; Liang, H. ; Luo, X. S. ; Cheng, X. X. ; Ding, J. W. ; Wu, D. J. ; Liu, L. M. ; Gao, X. L. ; Li, G. B . Organic-inorganic composite ultrafiltration membrane with anti-fouling and catalytic properties by in-situ co-casting for water treatment . J. Membr. Sci. , 2022 , 662 , 120984 .

Views

250

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Recent Progress in Thermally Resistant Polymer Nanofiltration Membranes

Related Author

GONG En-hui

WAN Ling-shu

LIANG Song-miao

LUO Xiao-wei

FAN Hong-yu

LIN Wan-ting

LI Wan-long

ZHANG Zi-lu

Related Institution

MOE Engineering Research Center of Membrane and Water Treatment Technology, Department of Polymer Science and Engineering, Zhejiang University

Vontron Technology Co, Ltd

⁰